再生粗骨料品质对混凝土抗溶蚀性能的影响

刘惠; 王震; 郝亚利; 朱平华; 王新杰; 陈春红

doi:10.11835/j.issn.2096-6717.2021.043

您当前的位置：

首页 >

文章列表页 >

再生粗骨料品质对混凝土抗溶蚀性能的影响

土木工程 | 更新时间：2023-03-07

- 再生粗骨料品质对混凝土抗溶蚀性能的影响
- Effect of quality of recycled coarse aggregate on the corrosion resistance of concrete
- 土木与环境工程学报 2023年45卷第2期页码：187-193
- 作者机构：
  
  常州大学环境与安全工程学院，江苏常州 213164
- 作者简介：
  
  刘惠（1989- ），女，博士，主要从事再生混凝土结构耐久性研究，E-mail：liuhui@cczu.edu.cn。
  朱平华（通信作者），男，博士，教授，E-mail：zph@cczu.edu.cn。
- 基金信息：
  
  国家自然科学基金(51278073;51878081;52078068);硅酸盐建筑材料国家重点实验室（武汉理工大学）开放基金(SYSJJ2020-14);常州市重点研发计划（应用基础研究）项目(CJ20200079)
- DOI：10.11835/j.issn.2096-6717.2021.043
  中图分类号： TU528.1
- 收稿：2021-01-15，
  
  纸质出版：2023-04-25
- 稿件说明：
移动端阅览
刘惠, 王震, 郝亚利, 等. 再生粗骨料品质对混凝土抗溶蚀性能的影响[J]. 土木与环境工程学报, 2023,45(2):187-193.

LIU Hui, WANG Zhen, HAO Yali, et al. Effect of quality of recycled coarse aggregate on the corrosion resistance of concrete[J]. Journal of Civil and Environmental Engineering, 2023, 45(2): 187-193.
刘惠, 王震, 郝亚利, 等. 再生粗骨料品质对混凝土抗溶蚀性能的影响[J]. 土木与环境工程学报, 2023,45(2):187-193. DOI： 10.11835/j.issn.2096-6717.2021.043.

LIU Hui, WANG Zhen, HAO Yali, et al. Effect of quality of recycled coarse aggregate on the corrosion resistance of concrete[J]. Journal of Civil and Environmental Engineering, 2023, 45(2): 187-193. DOI： 10.11835/j.issn.2096-6717.2021.043.

摘要

基于硝酸加速溶蚀试验方法，分别对100%取代率下不同品质（I类、Ⅱ类和Ⅲ类）再生粗骨料混凝土和天然粗骨料混凝土的抗溶蚀耐久性进行对比研究，并从宏观力学性能退化及内部微观结构损伤方面进一步揭示混凝土抗溶蚀性能经时劣化规律和损伤机理。研究结果表明：高品质再生骨料制备的混凝土抗压强度较高，与骨料物理性能具有良好的对应关系。在溶蚀环境下，再生粗骨料混凝土的抗压强度损失率、质量损失率、溶蚀深度随溶蚀龄期的增长而逐渐增大，但随着粗骨料品质的降低，却并不一定严格增大，会出现阶段性差异。由SEM图像可知，溶蚀前后，低品质骨料混凝土界面过渡区差异明显。由溶蚀深度与溶蚀时间的拟合公式可知，3类品质骨料制备的混凝土均满足软水环境中的水工结构使用要求，低品质（Ⅲ类）再生粗骨料混凝土可用于一代服役50 a的水利工程结构。

Abstract

Based on the method of nitric acid accelerated dissolution test

the comparative study on the corrosion resistance durability of natural aggregate concrete (NAC) and recycled aggregate concrete (RAC) prepared using 100% of recycled coarse aggregate (RCA) with different qualities (class I

class Ⅱ and class Ⅲ) is performed. The degradation law and damage mechanism of corrosion resistance of RAC are further revealed from the aspects of macroscopic mechanical property degradation and internal microstructure damage. The results show that the compressive strength of recycled concrete prepared by high-quality aggregate with better physical properties is higher

and there is a good correlation between them. In the corrosion environment

the compressive strength loss rate

mass loss rate and corrosion depth of recycled coarse aggregate concrete gradually increase with the increase of corrosion age

but not strictly increase with the decrease of coarse aggregate quality

and there are periodic differences in different periods. The SEM images show that the interfacial transition zone of low-quality aggregate concrete is obviously different before and after corrosion. According to the fitting formula of corrosion depth and corrosion time

the concrete prepared by three kinds of quality aggregate can meet the requirements of hydraulic structure in soft water environment

and the recycled coarse aggregate concrete with low quality (class Ⅲ) can be used for the hydraulic engineering structure with 50 years of service.

关键词

Keywords

references

马强 , 左晓宝 , 汤玉娟 . 环境水侵蚀下水泥净浆钙溶蚀的模拟与验证 [J]. 水利水运工程学报 , 2017 ( 3 ): 107 - 115 .

MA Q , ZUO X B , TANG Y J . Numerical simulation of calcium leaching process of hardened cement paste under action of environmental water [J]. Hydro-Science and Engineering , 2017 ( 3 ): 107 - 115 . (in Chinese)

周静海 , 吴迪 , 赵庭钰 , 等 . 废弃纤维再生混凝土受压徐变及预测模型 [J]. 土木与环境工程学报(中英文) , 2019 , 41 ( 6 ): 143 - 151 .

ZHOU J H , WU D , ZHAO T Y , et al . Pressure and creep characteristics of waste fiber recycled concrete and estimation model [J]. Journal of Civil and Environmental Engineering , 2019 , 41 ( 6 ): 143 - 151 . (in Chinese)

韩帅 , 李秋义 , 张修勤 , 等 . 再生粗骨料品质和取代率对再生混凝土抗冻性能影响 [J]. 中国海洋大学学报(自然科学版) , 2017 , 47 ( 1 ): 96 - 104 .

HAN S , LI Q Y , ZHANG X Q , et al . Influence of quality and substitution rate of recycled coarse aggregate on anti-freeze performance of recycled concrete [J]. Periodical of Ocean University of China , 2017 , 47 ( 1 ): 96 - 104 . (in Chinese)

GALVÍN A P , AGRELA F , AYUSO J , et al . Leaching assessment of concrete made of recycled coarse aggregate: Physical and environmental characterisation of aggregates and hardened concrete [J]. Waste Management , 2014 , 34 ( 9 ): 1693 - 1704 .

CHENG A , CHAO S J , LIN W T . Effects of leaching behavior of calcium ions on compression and durability of cement-based materials with mineral admixtures [J]. Materials (Basel, Switzerland) , 2013 , 6 ( 5 ): 1851 - 1872 .

PHUNG Q T , MAES N , JACQUES D , et al . Investigation of the changes in microstructure and transport properties of leached cement pastes accounting for mix composition [J]. Cement and Concrete Research , 2016 , 79 : 217 - 234 .

混凝土结构耐久性设计标准 : GB/T 50476—2019 [S]. 北京 : 中国建筑工业出版社 , 2019 .

Standard for design of concrete structure durability : GB/T 50476-2019 [S]. Beijing : China Architecture & Building Press , 2019 . (in Chinese)

肖建庄 , 雷斌 . 再生混凝土碳化模型与结构耐久性设计 [J]. 建筑科学与工程学报 , 2008 , 25 ( 3 ): 66 - 72 .

XIAO J Z , LEI B . Carbonation model and structural durability design for recycled concrete [J]. Journal of Architecture and Civil Engineering , 2008 , 25 ( 3 ): 66 - 72 . (in Chinese)

普通混凝土长期性能和耐久性能试验方法标准 : GB/T 50082—2009 [S]. 北京 : 中国建筑工业出版社 , 2009 .

Standard for test methods of long-term performance and durability of ordinary concrete : GB/T 50082-2009 [S]. Beijing : China Architecture & Building Press , 2009 . (in Chinese)

陈建奎 , 王栋民 . 高性能混凝土(HPC)配合比设计新法: 全计算法 [J]. 硅酸盐学报 , 2000 , 28 ( 2 ): 194 - 198 .

CHEN J K , WANG D M . New mix design method for HPC:Overall calculation method [J]. Journal of the Chinese Ceramic Society , 2000 , 28 ( 2 ): 194 - 198 . (in Chinese)

TAM V W Y , GAO X F , TAM C M . Microstructural analysis of recycled aggregate concrete produced from two-stage mixing approach [J]. Cement and Concrete Research , 2005 , 35 ( 6 ): 1195 - 1203 .

混凝土物理力学性能试验方法标准 : GB/T 50081—2019 [S]. 北京 : 中国建筑工业出版社 , 2019 .

Standard for test methods of concrete physical and mechanical properties : GB/T 50081-2019 [S]. Beijing : China Architecture & Building Press , 2019 . (in Chinese)

KIM Y , HANIF A , USMAN M , et al . Influence of bonded mortar of recycled concrete aggregates on interfacial characteristics:Porosity assessment based on pore segmentation from backscattered electron image analysis [J]. Construction and Building Materials , 2019 , 212 : 149 - 163 .

混凝土用再生粗骨料 : GB/T 25177—2010 [S]. 北京 : 中国标准出版社 , 2011 .

Recycled coarse aggregate for concrete : GB/T 25177-2010 [S]. Beijing : Standards Press of China , 2011 . (in Chinese)

韩帅 . 再生粗骨料品质和取代率对再生混凝土耐久性能的影响 [D]. 山东青岛 : 青岛理工大学 , 2015 .

HAN S . Influence of quality and substitution rate of recycled coarse aggregate on durability of recycled concrete [D]. Qingdao, Shandong : Qingdao Tehcnology University , 2015 . (in Chinese)

ZHANG H R , JI T , LIU H . Performance evolution of the interfacial transition zone (ITZ) in recycled aggregate concrete under external sulfate attacks and dry-wet cycling [J]. Construction and Building Materials , 2019 , 229 : 116938 .

柳俊哲 , 耿俊迪 , 巴明芳 , 等 . 亚硝酸盐对含氯盐砂浆内钢筋钝化膜组成的影响 [J]. 建筑材料学报 , 2018 , 21 ( 4 ): 536 - 541 .

LIU J Z , GENG J D , BA M F , et al . Effect of nitrite on passivation film composition of reinforcing bar in the mortar containing chloride [J]. Journal of Building Materials , 2018 , 21 ( 4 ): 536 - 541 . (in Chinese)

OLANIKE A O . Experimental investigation into the freeze-thaw resistance of concrete using recycled concrete aggregates and admixtures [J]. Civil Engineering and Architecture , 2014 , 2 ( 4 ): 176 - 180 .

SAITO H , DEGUCHI A . Leaching tests on different mortars using accelerated electrochemical method [J]. Cement and Concrete Research , 2000 , 30 ( 11 ): 1815 - 1825 .

PAVLÍK V . Corrosion of hardened cement paste by acetic and nitric acids part I: Calculation of corrosion depth [J]. Cement and Concrete Research , 1994 , 24 ( 3 ): 551 - 562 .

KAMALI S , MORANVILLE M , LECLERCQ S . Material and environmental parameter effects on the leaching of cement pastes: Experiments and modelling [J]. Cement and Concrete Research , 2008 , 38 ( 4 ): 575 - 585 .

混凝土结构设计规范 : GB 50010—2010 [S]. 北京 : 中国建筑工业出版社 , 2011 .

Code for design of concrete structures : GB 50010-2010 [S]. Beijing : China Architecture & Building Press , 2011 . (in Chinese)

ZHANG W L , DE WANG S , ZHAO P Q , et al . Effect of the optimized triple mixing method on the ITZ microstructure and performance of recycled aggregate concrete [J]. Construction and Building Materials , 2019 , 203 : 601 - 607 .

浏览量

下载量

CSCD

文章被引用时，请邮件提醒。

提交

工具集

关联资源

地质聚合物固化土研究现状及展望

生态混凝土绿色护坡的植生性与耐久性

渗滤液浸泡对碱渣固化污泥长期性能的影响

废弃纤维再生混凝土受压徐变及预测模型

基于微分等价递归算法的桥梁体系耐久性可靠度动态评估